Turner Access Higher Safety Total Access
Total Access Ethentic Chipmunk Data
Chipmunk Data Turner Access Ethentic

HIGH FINES FOLLOW FATAL LIFTING OPERATION

Management system failures left vital equipment unchecked

Two global companies have been sentenced after a workman died and another suffered life changing injuries during construction of an offshore wind farm.

The incident happened when a team of engineers were loading wind turbine blades onto a sea barge for delivery to Greater Gabbard, off the Suffolk coast, on 21 May 2010.

During the loading of wind turbine components at Harwich, a 2.11 tonne part of the blade transport arrangement fell crushing and fatally injuring one worker and seriously injuring another.

Chelmsford Crown Court heard both workers were employed by Siemens Windpower A/S (SWP) but were working for Fluor Ltd, the principal contractor.

The investigation carried out by HSE found serious safety failings in the two firms’ management systems for the loading operation, which allowed vital parts of equipment to go unchecked before being lifted.

Lift plans must consider all relevant risks

Following a four-week trial in July Fluor Ltd was found guilty of breaching Section 3 (1) of the Health and Safety at Work etc. Act 1974 and was today ordered to pay £275,000 in fines and £271,048 costs.

Siemens Windpower A/S (SWP) were charged with the same offence and also a Section 2 (1) breach of the same act, but pleaded guilty at an earlier stage. They were also sentenced today and ordered to pay £375,000 in fines with costs of £105,355.

Speaking after the hearing, HSE Inspector Julie Rayner said:

“This incident could easily have been avoided had suitable systems and procedures been in place to ensure that all loads were properly connected whilst being lifted.

Had the right questions been asked when the lift was being planned and had the bolt and two brackets holding the blade and frame together been checked before they were lifted, the death and serious injury of two workers could have been prevented.

This case clearly highlights the need to ensure that relevant information is considered when lift plans are produced to ensure that all of the relevant risks are considered.”

Latest Construction Health and Safety News

HSE ENFORCEMENT WEEKLY UPDATE 17th JAN 2018

hselogo1Prosecutions and enforcement notices weekly update and analysis

Read the rest of this article »

Posted on 18th January 2018

PARLIAMENT CALLS FOR WORKING AT HEIGHT ADVICE

Group of MPs seek to understand fatal fall causes and solutions

Read the rest of this article »

Posted on 18th January 2018

FIRM FINED OVER FATAL FRAGILE ROOFLIGHT FALL

Work at height not planned, supervised or carried out safely

Read the rest of this article »

Posted on 18th January 2018

EXCAVATOR CRUSHED DUMPER OPERATOR

Reversing excavator operations not separated from pedestrians

Read the rest of this article »

Posted on 12th January 2018

REFURB CONTRACTORS FINED £1.1 MILLION

Tenant fell 5m through fragile surface whilst walking to home

Read the rest of this article »

Posted on 12th January 2018

HSE ENFORCEMENT WEEKLY UPDATE 10th JAN 2018

hselogo1Prosecutions and enforcement notices weekly update and analysis

Read the rest of this article »

Posted on 10th January 2018

STRUCTURAL SAFETY BODY LATEST NEWSLETTER

CROSS publishes reports and expert comment on a range of issues

Read the rest of this article »

Posted on 10th January 2018

HSE REACH OUT TO RESOLVE RISK MANAGEMENT

Construction Industry Advisory Network (CONIAN) launched

Read the rest of this article »

Posted on 10th January 2018

HSE ENFORCEMENT WEEKLY UPDATE 4th JAN 2018

hselogo1Prosecutions and enforcement notices weekly update and analysis

Read the rest of this article »

Posted on 4th January 2018

FAILURE TO PROTECT PUBLIC FINED £600,000

Two elderly people injured during construction of disabled ramp

Read the rest of this article »

Posted on 2nd January 2018

MAINTENANCE AND MANAGEMENT FIRM FINED

Joist failed and workman fell during flat roof replacement works

Read the rest of this article »

Posted on 2nd January 2018

FALL ON BLOCK AND BEAM FLOORING SYSTEM

Contractors failed to respond to planned fall protection problems

Read the rest of this article »

Posted on 2nd January 2018

FIRMS FAILED TO INSTALL FLOOR AS DESIGNED

Principal contractor penalised for not spotting contractor error

Read the rest of this article »

Posted on 2nd January 2018

LINTEL COLLAPSED DURING LOWERING OPERATION

Two workers injured as support props and structure topple

Read the rest of this article »

Posted on 2nd January 2018

CDM 2015: SEEING THE WOOD FOR THE TREES

End of year reflections on CDM 2015, health, safety and harm

Read the rest of this article »

Posted on 21st December 2017

FESTIVE GREETINGS TO ALL OUR READERS

Read the rest of this article »

Posted on 20th December 2017

HSE ENFORCEMENT WEEKLY UPDATE 20th DEC 2017

hselogo1Prosecutions and enforcement notices weekly update and analysis

Read the rest of this article »

Posted on 20th December 2017

LORRY DRIVER PROSECUTED AFTER ROAD DEATH

Road worker died during motorway resurfacing project

Read the rest of this article »

Posted on 20th December 2017

MAJOR CONTRACTOR FINED £1.8M OVER ROAD DEATH

Road planer operation put roadworks pedestrians at risk of injury

Read the rest of this article »

Posted on 20th December 2017

MANAGER PROSECUTED OVER APPRENTICE INJURY

Untrained young worker fell through fragile rooflight

Read the rest of this article »

Posted on 20th December 2017

PUBLIC AND WORKERS EXPOSED TO ASBESTOS RISK

Client and contractor failed to identify and assess asbestos presence

Read the rest of this article »

Posted on 20th December 2017

RESTRAINT SAVES WORKER EJECTED FROM MEWP

Firms failed to separate crane and elevated mobile work platform

Read the rest of this article »

Posted on 20th December 2017

HSE PROSECUTE OVER POOR SILICA DUST CONTROL

Principal contractor failures led to gross exposure to RCS

Read the rest of this article »

Posted on 15th December 2017

HSE ENFORCEMENT WEEKLY UPDATE 13th DEC 2017

hselogo1Prosecutions and enforcement notices weekly update and analysis

Read the rest of this article »

Posted on 15th December 2017

BUILDING INFORMATION MODELLING AND CDM 2015

Major contractor explains BIM risk mitigation opportunities

Read the rest of this article »

Posted on 15th December 2017
Turner Access Chipmunk Data
Total Access Ethentic
Higher Safety Turner Access